Robert S. Reichard
Other Positive Signs
Uncle Sam's revised data also provide other indications of an improving industry climate. For one, they show that the big capacity cutbacks of the past few decades are beginning to slow down. Thus, production potential for all mills has declined only about 4 percent annually over the past two years. That's a fair-sized slowdown from the 5- to 6-percent attrition noted over earlier years. Moreover, given the outlook for relatively steady demand, this upbeat trend should continue. Also pointing to smaller capacity declines: U.S. mills still seem willing to invest hefty sums on new facilities. The National Council of Textile Organizations finds that mills spent nearly $17 billion on new plant and equipment over the past decade. This spending is clearly paying off in terms of impressive productivity gains. Indeed, a comparison of mill equipment and output numbers suggests mill efficiency is rising at nearly a 3.5-percent annual rate — not that different from the pace noted for all U.S. manufacturing. And it's pretty much the same for the U.S. apparel industry. Capacity shrinkage has dropped down to only a 3-percent annual rate — again, well under the huge declines of the previous two decades, when more than two-thirds of the U.S. apparel industry disappeared. And here, too, there's been continuing capital investment, for both modernization and improved efficiency.
Operating Rates Up
Finally, a few words on how the new output and capacity numbers are affecting mill and apparel utilization rates: Here, too, the news is basically positive. More to the point: The new government statistics show production increasing relative to available capacity. These ratios are still nowhere near the levels at which U.S. industries would prefer to operate. Nevertheless, any increases are welcome, as they help dampen competitive pressures. As for the actual numbers: Domestic textile mills are currently producing at nearly 70 percent of their potential — 13-percent above their 2009 low, though still far under the 85- to 90-percent levels prevailing through most of the 1990s. Similar improvement is noted for the apparel sector — with a 70-percent reading running some 10 percentage points above the 2009 low, though well under the 85-percent levels of two decades ago. As suggested earlier, all the above has to some extent helped reduce the cutthroat price-cutting of recent years. Indeed, it may well be why textile and apparel profits have climbed back into modest positive territory. Moreover, factor in the likelihood of steady demand and the absence of any cost pressures, and industry earnings could well inch up a bit more in 2013 and 2014.
Click here to view Textile Barometers